车库门维修、窗使用较频繁，也容易被损坏，平时若能多动一些脑筋，在使用与保养上掌握一些车库门维修保养的技巧，就可给生活带来方便。下面我们就一起来了解下车库门的维修和保养方法。

　　Garage door maintenance and window use are frequent and easily damaged. If you can use your brain more and master some garage door maintenance skills in use and maintenance, it can bring convenience to life. Let's learn about the repair and maintenance methods for garage doors together.

　　车库门的常见故障

　　Common faults of garage doors

　　1、用手动开关或遥控器不能启动驱动装置，驱动装置没有接通电源，手动开关或遥控接收板断路，运行次数过多导致电机热保护，检查插座、插头、手动开关、保险管熔丝，检查手动开关及遥控接收板接线，重新定位行程开关以增加行程；

　　1. The driving device cannot be started with a manual switch or remote control, the driving device is not powered on, the manual switch or remote control receiving board is open circuited, and the motor thermal protection is caused by excessive operation. Check the socket, plug, manual switch, fuse tube, and wiring of the manual switch and remote control receiving board. Reposition the travel switch to increase the travel;

　　2、门关不严或开不完全，行程开关位置调节不正确，重新定位行程开关以增加行程；

　　2. The door is not tightly closed or fully opened, and the position adjustment of the travel switch is incorrect. Reposition the travel switch to increase the travel;

　　3、手动开关能控制驱动装置而遥控器不能，遥控器未对码，遥控系统故障，按照说明书指导完成对码操作，更换遥控器内部电池，请维修人员检查接收控制板；

　　3. The manual switch can control the driving device, but the remote control cannot. The remote control is not properly coded, indicating a malfunction in the remote control system. Follow the instructions in the manual to complete the coding operation, replace the internal battery of the remote control, and ask maintenance personnel to check the receiving control board;

　　4、门未关紧就自动反向运行或开门时未接触行程开关就中途停止运行，开关门阻力大于设置启闭负载力了障碍感应系统，连杆长度调节不当，拉开离合装置，检验门体与扭簧是否平衡、启闭是否灵活，增大开闭负载力，在门关闭时调节连杆长度；

　　4. The door automatically runs in reverse before it is tightly closed or stops running halfway without touching the travel switch when opening the door. The resistance to opening and closing the door is greater than the set load force, activating the obstacle sensing system. The length of the connecting rod is not adjusted properly. The clutch device is opened to check whether the door body and torsion spring are balanced and whether the opening and closing are flexible. The opening and closing load force is increased, and the length of the connecting rod is adjusted when the door is closed;

　　5、门体单向运行行程开关损坏或行程开关线短路，光电开关光路上有障碍物 启闭负载力调节没有到位，检查行程开关及行程开关接线，光电形状光路上的障碍物，重新调节启闭负载力；

　　5. The one-way travel switch of the door is damaged or the travel switch wire is short circuited. There are obstacles on the photoelectric switch optical path, and the load force adjustment for opening and closing is not in place. Check the travel switch and its wiring, remove the obstacles on the photoelectric shaped optical path, and readjust the load force for opening and closing;

　　车库门维修方法

　　Garage door repair method

　　1：检查车库内部的金属轨道。查看将轨道固定到墙壁的安装支架。如果支架松了，请拧紧螺栓或螺钉。将车库门关上，在车？库内部检查轨道是否有凹陷、弯曲或变平的地方。如果有任何损坏之处，请用橡皮锤，或用一块废木料垫着锤子敲打这些地方。如果轨道严重损坏，您必须更换。

　　1: Check the metal tracks inside the garage. Check the installation bracket that fixes the track to the wall. If the bracket is loose, please tighten the bolts or screws. Close the garage door, in the car? Inspect the tracks inside the warehouse for any dents, bends, or flattening. If there is any damage, please use a rubber hammer or use a piece of scrap wood to cushion the hammer and strike these areas. If the track is severely damaged, you must replace it.

　　2：用水平仪检查轨道，确保轨道在同一水平线上。水平轨道应当略向车库后部倾斜，如果是卷帘门，轨道的纵向部分应精确垂直。在车库的墙壁上，两条轨道必须处于同一高度。如果轨道没有准确对齐，请将固定安装支架的螺钉或螺栓拧松，但不要把它们取下来，然后小心地敲打轨道，使它们移动到适当的位置。用水平仪重新检查轨道，确保它们处于正确的位置；然后将安装支架上的螺钉或螺栓拧紧。

　　2: Use a spirit level to check the track and ensure that it is on the same horizontal line. The horizontal track should be slightly inclined towards the rear of the garage, and if it is a rolling shutter door, the longitudinal part of the track should be precisely vertical. On the walls of the garage, the two tracks must be at the same height. If the track is not aligned accurately, loosen the screws or bolts that secure the mounting bracket, but do not remove them, then carefully tap the track to move them to the appropriate position. Recheck the tracks with a spirit level to ensure they are in the correct position; Then tighten the screws or bolts on the installation bracket.

　　3：用高浓度家用清洁剂清洗轨道，去除污垢和硬化的油脂。将转轴彻底清洗干净，然后将轨道和转轴擦干。

　　3: Clean the track with a high concentration household cleaner to remove dirt and hardened grease. Thoroughly clean the shaft, then dry the track and shaft.

　　4：将石墨粉撒在轨道上，将家用润滑油或硅树脂喷在转轴上，或者在轨道和转轴上喷洒车库门专用润滑油喷剂，以起到润滑作用。如果有滑轮，请您使用和用在转轴上的相同的润滑剂润滑。

　　4: Sprinkle graphite powder on the track, spray household lubricating oil or silicone resin on the shaft, or spray garage door specific lubricating oil spray on the track and shaft to provide lubrication. If there are pulleys, please lubricate them with the same lubricant as used on the shaft.

　　车库门保养

　　Garage door maintenance

　　我们主要的工作就是经常对轨道进行清洁，把轨道内部的杂物都去除干净，这样就不会影响门体的运动，如果门体有卡住现象发生，我们应该检查扭簧和配件是否牢固，如有出现损坏的现象发生我们应该及时维修和更换。定期对电动车库门的表面进行清洁，以免使用久了导致锈蚀等现象发生，在清洁的时候不能使用化学清洁剂来清洗，这样会产生氧化对车库门的漆面造成脱落。

　　Our main job is to regularly clean the track, removing all debris inside the track so that it does not affect the movement of the door. If the door gets stuck, we should check whether the torsion spring and accessories are secure. If there is any damage, we should repair and replace them in a timely manner. Regularly clean the surface of the electric garage door to prevent rusting and other phenomena caused by prolonged use. Chemical cleaning agents should not be used during cleaning, as this can cause oxidation and peel off the paint surface of the garage door.

　　我们的生活已经离不开汽车的使用，同时就必须要有车库，但是我们在使用车库的时候不要忽视了它的保养工作，到时候出现问题还是我们自己来处理，它的成倍大于保养工作，因此大家应该分清轻重，这样才不会影响正常停车。

　　Our lives are inseparable from the use of cars, and at the same time, we must have a garage. However, when we use a garage, we should not ignore its maintenance work. If there are problems, we will have to deal with them ourselves. Its multiplication is definitely greater than maintenance work. Therefore, everyone should distinguish between the importance and importance, so as not to affect normal parking.

　　本文由 济南卷帘门 友情奉献.更多有关的知识请点击 http://www.jnzxmy.com    真诚的态度.为您提供为的服务.更多有关的知识我们将会陆续向大家奉献.敬请期待.

　　This article is a friendly contribution from Jinan Rolling Shutter Doors For more related knowledge, please click http://www.jnzxmy.com Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.